Hormann Rollmatic Roller Door
And now for a roller door with a difference.... This is a very high security door with European standard approval ratings which Hormann have designed from the bottom up rather than copying all the other products on the market.
With the RollMatic, standards and quality have gone to the next level.
The prime design differences are that the door uses a tension spring to provide the counter-balancing force for lifting the curtain, this allows the use of a DC motor which can 'sense' an obstruction and auto-reverse. The motor and control system is proven technology taken from the Promatic electric opener used on retractable and sectional doors. It's basically a Promatic split in half, the control side of things mounts to the wall and the motor sits under the roll driving with a chain.
- Fully enclosed roll for keeping the mechanics clean (longer life) and better security
- Reliable safety system (hurray no more electrics as with all other doors)
- Storm anchors fitted to sides of curtain to 'hook' the curtain into the guides - class 5
(155mph) wind load and much improved security
- Easy opening in the event of a power cut - pull the toggle and lift the door (no endless
winding necessary as with all other doors)
- Easy installation - motor is used to lift the curtain up onto the axle rather than having to
lift it over manually as with all other doors
- Soft-start soft-stop motor
- Smooth near silent operation
- Better warranty!! 10-years!
It uses 77mm high, 12mm thick smooth faced slats which have a higher thermal properties that the other roller doors on the market and has a 290mm head requirement (335mm on doors 2300m and higher) which gives a drive-through height 360mm lower than the finished ceiling enabling the door to be fitted in many more garages than the typical steel roller doors.
The RollMatic roller door offers very good security as the door is held in 100mm wide Aluminium 'C'-shaped guides all the way down both sides of the door from floor to lintel and when the door is shut a very effective locking mechanism is automatically engaged. The doors has draft proofing as they have a weather seal across the base of the door and strips in the guides; however there is no draft seal at the top.
This door is available as an electric door with two remote controls and safety system' for stopping the door if it touches an obstruction. The motor assy can only be fitted on the left hand side (in looking out) a longer cable can be purchased if you would prefer the control box on the opposite side of the garage.
A manual version door is also available.
A matching side door is also available - ask for details.
Hormann doors are built to take the wear and tear of life and they are able to provide an impressive warranty as long as the door is reasonably maintained:
10-year safe and reliable operation
5-year springs, wire cables, tracks, guide rollers and hinges
5-year operator mechanics, motor and motor control system
Delivery time for a RollMatic door is approximately 3/4 weeks. Delivery to UK mainland is included in the prices below.
Colours at standard charge: Traffic White, Terra Brown, Light Grey, Ruby Red, Moss Green, Steel Blue, Signal Blue & Deep Black.
Colours at higher charge: Textured Golden Oak Woodgrain and Textured Rosewood Woodgrain.
Golden Oak and Rosewood curtains are supplied with a matching bottom slat and guides, however, the inner faces are brown.
Full box enclosures
This product comes with a full box enclosure as standard and are coloured to match the door automatically. Note the inner face of the box is always in white. Doors over 2500mm guide height can opt out of the enclosure for a saving of £7 per meter width.
If you have no other access into the garage other than through the garage door itself then you must fit an External Manual Overide; this will enable you to pull the release toggle and manually lift the curtain in the event of a power cut - it is secured by a key/lock barrel to prevent unauthorised use. Cost £90 inc VAT.
Control box location
The motor assy can only be fitted on the left hand side (in looking out) a longer cable can be purchased if you need the control box on the right hand side of the garage. Cost £34 inc VAT.
Two (or more) doors controlled by one remote control
If you are fitting two or more doors you can easily cross programme the remotes such that each button on the remote will operate a different door.
Additional remote controls
Additional remote controls are available from £48 inc VAT, see the full list of available models at our sister website